Advantech PCA-6008VG User Manual Page 1

User ManualPCA-6008VGCeleron© M Processor Card with VGA/ Single Gigabit LAN/ HISA/ (400 MHz FSB)

PCA-6008VG User Manual xer ... 182.13 ATX Feature Connector (JATXF1)...

xi PCA-6008VG User Manual 3.5.13 DVMT/ FIXED Memory Size ... 303.5.14 Boot Display...

PCA-6008VG User Manual xii3.9.4 CPU FAN Speed... 383.9.5 VCORE and Other Voltage

xiii PCA-6008VG User Manual Table C.5: VGA connector (CN7)... 73C.6 RS-232 Serial Port (COM1, COM2) ...

PCA-6008VG User Manual xiv

Chapter 11 Hardware Configuration

PCA-6008VG User Manual 21.1 IntroductionThe PCA-6008 is designed with the Intel 910GMLE chipset and ICH6M (I/O control-ler) to support the 400 MHz Fro

3 PCA-6008VG User ManualChapter 1 Hardware Configuration1.3 Specifications1.3.1 System CPU: Intel Celeron M 600 MHz, FSB 400 MHz. Advantech also cert

PCA-6008VG User Manual 41.3.6 Industrial Features Watchdog timer: Can generate a system reset or IRQ11. The watchdog timer is programmable, with each

5 PCA-6008VG User ManualChapter 1 Hardware ConfigurationTable 1.1: JumpersCMOS1 CMOS ClearJWDT1 Watchdog timer output selectionJSETCOM2 COM2 RS-232/42

PCA-6008VG User Manual iiCopyrightThe documentation and the software included with this product are copyrighted 2008by Advantech Co., Ltd. All rights

PCA-6008VG User Manual 61.5 Board Layout: Jumper and Connector LocationsFigure 1.1: Jumper and Connector locationsAC97SMBUS1JWDT1+JOBS1+JIR1KBMS2KBMS1

7 PCA-6008VG User ManualChapter 1 Hardware Configuration1.6 PCA-6008 Block Diagram1.7 Safety PrecautionsFigure 1.2: Warning!Always completely disconn

PCA-6008VG User Manual 81.8 Jumper SettingsThis section provides instructions on how to configure your single board computer bysetting the jumpers. It

9 PCA-6008VG User ManualChapter 1 Hardware Configurationrecover from a software failure or an EMI problem. The J2 jumper settings control theoutcome o

PCA-6008VG User Manual 101.9.1 CPU FSB and Memory SpeedThe PCA-6008 can accept DDRII SDRAM memory chips without parity. Also note:The PCA-6008 accepts

Chapter 22 Connecting Peripherals

PCA-6008VG User Manual 122.1 IntroductionYou can access most of the connectors from the top of the board while it is installedin the chassis. If you h

13 PCA-6008VG User ManualChapter 2 Connecting PeripheralsYou can attach up to two floppy disk drives to the PCA-6008's on board controller.You ca

PCA-6008VG User Manual 142.5 USB Ports (USB12, USB34)The PCA-6008 provides up to four USB (Universal Serial Bus) interface ports. TheUSB interface co

15 PCA-6008VG User ManualChapter 2 Connecting Peripherals2.7 Ethernet Connector (LAN1)The PCA-6008 is equipped with a single high performance 1000 Bas

iii PCA-6008VG User Manual Declaration of ConformityCEThis product has passed the CE test for environmental specifications. Test conditionsfor passing

PCA-6008VG User Manual 162.9 PS/2 Keyboard/Mouse Connector (KBMS1)One 6-pin mini-DIN connector (KBMS1) on the card mounting bracket provides con-necti

17 PCA-6008VG User ManualChapter 2 Connecting Peripherals2.11 CPU Fan Connector (CPUFAN1)The PCA-6008 provides a 4 pin CPU fan connector.2.12 Front Pa

PCA-6008VG User Manual 182.12.2 Reset (JFP1 / RESET)Many computer cases offer the convenience of a reset button. Connect the wire forthe reset button.

19 PCA-6008VG User ManualChapter 2 Connecting Peripherals2.13 ATX Feature Connector (JATXF1)Connect to the JATFX1 connector on the Advantech backplane

PCA-6008VG User Manual 20In addition to the one EIDE interface (up to two devices), the PCA-6008 provides fourhigh performance serial ATA interfaces (

21 PCA-6008VG User ManualChapter 2 Connecting PeripheralsJIR1 supports the optional wireless infrared transmitting and receiving module. Thismodule mo

PCA-6008VG User Manual 222.20 GPIO Pin Header (GPI01)The PCA-6008 specifically has a 14-pin General Purpose I/O interface for port 80functions used in

Chapter 33 Award BIOS Setup

PCA-6008VG User Manual 243.1 IntroductionAward’s BIOS ROM has a built-in setup program that allows users to modify thebasic system configuration. This

25 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.3 Standard CMOS SetupFigure 3.2 Standard CMOS Features Screen3.3.1 Date3.3.2 The Date Format is &

PCA-6008VG User Manual ivTable 1.2: PCA-6008 DDR memory compatibility tableBrand Size Speed ECC Vendor PN Advantech PNMemory Apacer 1GB DDR2 533N 78.

PCA-6008VG User Manual 263.3.6 Halt OnThis category determines whether the system will halt or not on start-up when anerror is detected during power u

27 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.4.2 Hard Disk Boot PrioritySet hard disk boot device priority.3.4.3 Virus WarningEnable virus war

PCA-6008VG User Manual 283.4.14 Typematic Delay (msec)Typematic delay is the time interval between the appearances of two consecutivecharacters, when

29 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.5 Advanced Chipset FeaturesBy choosing the “Advanced Chipset Features” option from the “Initial S

PCA-6008VG User Manual 30precharge. If no sufficient time is allowed for the RAS to accumulate its charge beforeDRAM refresh, refreshing may be incomp

31 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.5.14 Boot DisplayYou can select the display type for your computer equipment. Choices for this op

PCA-6008VG User Manual 323.6.1 IDE HDD Block ModeIf your IDE hard drive supports block mode select Enabled for automatic detection ofthe optimal numbe

33 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.6.7 USB Keyboard/Mouse SupportSelect Enabled if user plans to use an USB keyboard. The choices ar

PCA-6008VG User Manual 343.6.15 IR Transmission DelayThis item allows you to enable/disable IR transmission delay. The choices:"Enabled", &q

35 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.7 Power Management SetupThe power management setup controls the single board computer's “gre

v PCA-6008VG User Manual Document FeedbackTo assist us in making improvements to this manual, we would welcome commentsand constructive criticism. Ple

PCA-6008VG User Manual 36There are three selections for Power Management, and they have fixed mode set-tings.Table 3.1: D Power Down = 15 min.3.7.5 V

37 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.7.14 PowerOn by AlarmThe Choice: “Enabled”,”Disabled”.3.7.15 Primary IDE 0When Enabled. the syste

PCA-6008VG User Manual 383.8.5 Maximum Payload SizeIt allows you to set the maximum TLP payload size for the PCI Express devices. Set-ting options: [1

39 PCA-6008VG User ManualChapter 3 Award BIOS Setup3.10 Frequency / Voltage ControlFigure 3.12 Spread Spectrum Control screen3.10.1 Spread SpectrumThi

PCA-6008VG User Manual 403.12 Save & Exit SetupIf you select this and press <Enter>, the values entered in the setup utilities will berecord

Chapter 44 Chipset Software Install Utility

PCA-6008VG User Manual 424.1 Before you BeginTo facilitate the installation of the enhanced display device drivers and utility soft-ware, you should r

43 PCA-6008VG User ManualChapter 4 Chipset Software Install Utility2. A message pops up telling you to install the CSI utility before other device dri

PCA-6008VG User Manual 445. Click "Next" when you see the following messages.

45 PCA-6008VG User ManualChapter 4 Chipset Software Install Utility6. When the following message appears, click "Finish" to complete the ins

PCA-6008VG User Manual vi15. The power cord or plug is damaged.16. Liquid has penetrated into the equipment.17. The equipment has been exposed to mois

PCA-6008VG User Manual 46

Chapter 55 VGA Setup

PCA-6008VG User Manual 485.1 IntroductionThe Intel 910GMLE integrated graphics controller provides an analog display portthrough SDVO ports. You need

49 PCA-6008VG User ManualChapter 5 VGA Setup.3. Click "Finish" to complete the installation and restart the computer now or later.

PCA-6008VG User Manual 50

Chapter 66 LAN Configuration

PCA-6008VG User Manual 526.1 IntroductionThe PCA-6008 features single Gigabit Ethernet network interface. With the RealtekRTL8111B GbE controller desi

53 PCA-6008VG User ManualChapter 6 LAN Configuration6.4 Win XP Driver Setup (Realtek RTL8111B)1. Insert the driver CD into your system's CD-ROM d

PCA-6008VG User Manual 544. Click "Finish" to complete the installation.

Chapter 77 USB 2.0 Configuration

vii PCA-6008VG User Manual Wichtige Sicherheishinweise1. Bitte lesen sie Sich diese Hinweise sorgfältig durch.2. Heben Sie diese Anleitung für den spä

PCA-6008VG User Manual 567.1 IntroductionThe PCA-6008 is designed with Intel ICH6M which supports both USB1.1 and USB2.0 high-speed transmission. It r

Appendix AA Programming the Watchdog

PCA-6008VG User Manual 58A.1 Programming the Watchdog TimerThe PCA-6008's watchdog timer can be used to monitor system software operationand take

59 PCA-6008VG User ManualAppendix A Programming the WatchdogUnlock W83627HSelect register of watchdog timerEnable the function ofthe watchdog timerUse

PCA-6008VG User Manual 60Table A.1: Watchdog Timer RegistersAddress of register (2E) AttributeRead/Write Value (2F) and description87 (hex) ----- Writ

61 PCA-6008VG User ManualAppendix A Programming the WatchdogA.1.4 Example Program1. Enable watchdog timer and set 10 sec. as timeout interval;--------

PCA-6008VG User Manual 62Mov al,07h ; Select registers of watchdog timerOut dx,alInc dxMov al,08hOut dx,al ;--------------------

63 PCA-6008VG User ManualAppendix A Programming the WatchdogMov al,30hOut dx,alInc dxMov al,01hOut dx,al ;---------------------------------

PCA-6008VG User Manual 64Dec dx ; lock W83627HF Mov al,0aahOut dx,al5. Generate a time-out signal without timer counting;--------------

Appendix BB Programming the GPIO

PCA-6008VG User Manual viiiSafety Precaution - Static ElectricityFollow these simple precautions to protect yourself from harm and the products fromda

PCA-6008VG User Manual 66B.1 Sample Code;------------------------------------------------------------; MTEST1 _M_HL=05 GP10-13=GPO GP14-17=GPI;

67 PCA-6008VG User ManualAppendix B Programming the GPIO MOV AH,01H ; INT 21H ; ENDM

PCA-6008VG User Manual 68 mov al,0f0h ; out dx,al ;-Index (F0) mov dx,2fh ; mov

Appendix CC Pin Assignments

PCA-6008VG User Manual 70C.1 IDE Hard Drive Connector (IDE1)Table C.1: IDE hard drive connector (IDE1)Pin Signal Pin Signal1 IDE RESET* 2 GND3 DATA 7

71 PCA-6008VG User ManualAppendix C Pin AssignmentsC.2 Floppy Drive Connector (FDD1)Table C.2: Floppy drive connector (FDD1)Pin Signal Pin Signal1 GND

PCA-6008VG User Manual 72C.3 Parallel Port Connector (LPT1)C.4 USB Connector (USB12, USB34)Table C.3: Parallel port connector (CN4)Pin Signal Pin Sign

73 PCA-6008VG User ManualAppendix C Pin AssignmentsC.5 VGA Connector (VGA1)51511110 6Table C.5: VGA connector (CN7)Pin Signal Pin Signal1RED 9 VCC2 GR

PCA-6008VG User Manual 74C.6 RS-232 Serial Port (COM1, COM2)C.7 PS/2 Keyboard/ Mouse Connnector (KBMS1)C.8 External Keyboard Connector (KBMS2)Table C.

75 PCA-6008VG User ManualAppendix C Pin AssignmentsC.9 CPU Fan Power Connector (CPUFAN1)C.10 Power LED & Keyboard Lock Connector (JFP2)You can use

ix PCA-6008VG User Manual ContentsChapter 1 Hardware Configuration...11.1 Introduction ...

PCA-6008VG User Manual 76C.11 External Speaker Connector (JFP2/ SPEAKER)The single board computer has its own buzzer. You can also connect it to the e

77 PCA-6008VG User ManualAppendix C Pin AssignmentsC.15 ATX Soft Power Switch (JFP1/ PWR_SW))C.16 H/W Monitor Alarm (JOBS1)C.17 AC-97 Audio Interface

PCA-6008VG User Manual 78C.18 SM Bus Connector (JFP2/ SNMP)C.19 Case Open Connector (JCASE)C.20 LAN1 and LAN2 connector (LANLED1) 11 GND 12 N/CTable

79 PCA-6008VG User ManualAppendix C Pin AssignmentsC.21 GPIO Pin Header (GPIO1) Table C.21: GPIO pin header (GPIO1)Pin Signal Pin Signal1 GPIO_PORT80

PCA-6008VG User Manual 80C.22 System I/O PortsC.23 DMA Channel AssignmentsTable C.22: System I/O portsAddr. range (Hex) Device000-01F DMA controller02

81 PCA-6008VG User ManualAppendix C Pin AssignmentsC.24 Interrupt AssignmentsC.25 1st MB Memory MapC.26 PCI Bus MapTable C.24: Interrupt assignmentsP

www.advantech.comPlease verify specifications before quoting. This guide is intended for referencepurposes only.All product specifications are subject