Advantech PCA-6184 User Manual

PCA-6184Full-size socket 478Intel® Pentium® 4 processor-based PCI/ISAbus CPU card User’s Manual

PCA-6184 User’s Manual 2Chapter 1 Hardware Configuration1.1 IntroductionThe PCA-6184 Series all-in-one industrial grade single board computer is a h

PCA-6184 User’s Manual 92Out dx,al ;-----------------------------------------------------------Mov al,07h ; Select registers of

93 Appendix B AppendixBI/O Pin AssignmentsThis appendix contains information of a detailed or specialized nature. It includes:• IDE Hard Drive Conn

PCA-6184 User’s Manual 94Appendix B Pin AssignmentsB.1 IDE Hard Drive Connector(CN1, CN2)* low activeTable B.1: IDE hard drive connector (CN1, CN2)

95 Appendix B B.2 Floppy Drive Connector (CN3)* low activeTable B.2: Floppy Drive Connector (CN3)Pin Signal Pin Signal1 GND 2 FDHDIN3GND 4N/C5 DATA

PCA-6184 User’s Manual 96B.3 Parallel Port Connector (CN4)* low activeTable B.3: Parallel Port Connector (CN4)Pin Signal Pin Signal1 STROBE* 14 AUTOF

97 Appendix B B.4 USB Connector (CN6)B.5 VGA Connector (CN7)Table B.4: USB Connector (CN6)Pin USB1 Signal Pin USB2 Signal1+5 V 6+5 V2 UNV- 7 UV-3

PCA-6184 User’s Manual 98B.6 Ethernet Base-T Connector (CN8, CN34)B.7 COM1/COM2 Serial Port (CN9, CN10)Table B.6: Ethernet 10/100Base-T RJ-45 Connec

99 Appendix B B.8 Keyboard and Mouse Connector (CN11)B.9 External Keyboard Connector (CN12)Table B.8: Keyboard and Mouse Connector (CN 11)Pin Signa

PCA-6184 User’s Manual 100B.10 IR Connector (CN13)B.11 CPU Fan Power Connector (CN14)Table B.10: IR Connector (CN 13)Pin Signal1+5 V2N/C3 IR_RX4GND5

101 Appendix B B.12 Power LED and Keyboard Lock (CN16)You can use an LED to indicate when the CPU card is on. Pin 1 of CN16 supplies the LED's

3Table 1.1: PCA-6184 series comparison tableModel PCA-6184V-00A2 PCA-6184VE-00A2CPU : Single Intel ® Pentium® 4/Celeron Socket 478 processorVVChipset

PCA-6184 User’s Manual 102B.14 Reset Connector (CN18)B.15 HDD LED Connector (CN19)Table B.14: Reset Connector (CN 18)Pin Signal1 Reset2GNDTable B.15

103 Appendix B B.16 ATX Feature Connector (CN20)B.17 ATX Soft Power Switch (CN21)Table B.16: ATX Feature Connector (CN 20)Pin Signal1PS-ON2VCC3 VCC

PCA-6184 User’s Manual 104B.18 AC-97 Audio Interface (CN43)B.19 Extension I/O Board Connector (CN27)Table B.18: System I/O ports1 VCC 2 GND3 SYNC

105 Appendix B B.20 Extension I/O Board Connector (CN28)Table B.20: Extension I/O Board Connector (CN 28)Pin Signal Pin Signal1 TXC+ (DVI) 11 TX0+ (

PCA-6184 User’s Manual 106B.21 SM Bus Connector (CN29)B.22 System I/O PortsTable B.21: SM Bus Connector (CN 29)Pin Signal1SMB_DATA2SMB_CLKTable B.22

107 Appendix B B.23 DMA Channel Assignments0A0~0A1 Programmable interrupt controller0A2~0BF Motherboard resources0C0~0DF Direct memory access contro

PCA-6184 User’s Manual 108B.24 Interrupt AssignmentsB.25 1st MB Memory MapTable B.24: Interrupt Assignments Interrupt # Interrupt assignments0 (ISA)

109 Appendix B B.26 PCI Bus MapTable B.26: PCI bus mapFunction Device_ID INT# Pin GNT# PinOnboard LAN1 AD21 INTG GNTEOnboard LAN2 AD20 INTH GNTAISA

PCA-6184 User’s Manual 110

PCA-6184 User’s Manual 41.2 Features1. Onboard hardware monitoring: System healthy status including CPU fan, CPU temperature and system voltages leve

51.3 Specifications1.3.1 System• CPU: Intel Pentium® 4/Celeron® up to 2GHz and the above, FSB 533/400 MHz • BIOS: Award Flash BIOS, 4 Mb • System

PCA-6184 User’s Manual 6• AC-97 Audio: PCA-6184 can provide audio function. (Require the optional audio extension module PCA-AUDIO-00A11.3.4 VGA int

71.4 Jumpers and ConnectorsConnectors on the PCA-6184 board link it to external devices such as hard disk drives and a keyboard. In addition, the boa

PCA-6184 User’s Manual 8CN20 ATX feature connectorCN21 ATX soft power switchCN22 HW Monitor Alarm Close: Enable OBS Alarm Open: Disable OBS AlarmCN27

91.5 Board Layout: Jumper and Connector LocationsFigure 1.1: Jumper and connecter locationsCN46CN14CN16CN17CN19CN21CN2DIMM2DIMM1CN1CPU CN30J2J1CN13CN

PCA-6184 User’s Manual 10Figure 1.2: Extension I/O daughter board2,30, 121

111.6 Safety Precautions 1.7 Jumper SettingsThis section provides instructions on how to configure your card by set-ting jumpers. It also includes t

PCA-6184 User’s Manual iiCopyright This document is copyrighted, 2

PCA-6184 User’s Manual 121.7.2 CMOS clear (J1)The PCA-6184CPU card contains a jumper that can erase CMOS data and reset the system BIOS information. N

131.8 System MemoryThe PCA-6184 contains two sockets for 184-pin dual memory modules (DIMMs). All these sockets accept only 2.5 V DDR200/DDR266 SDRAM

PCA-6184 User’s Manual 141.11 CPU InstallationThe PCA-6184 provides socket 478 for an Pentium® 4 or Celeron® pro-cessor. The CPU on the board must ha

15CHAPTER 2Connecting PeripheralsThis chapter tells how to connect peripherals, switches, and indicators to the PCA-6184 board.

PCA-6184 User’s Manual 16Chapter 2 Connecting Peripherals2.1 Primary (CN1) and Secondary (CN2) IDE Connec-torsYou can attach up to four IDE (Integra

172.2 Floppy Drive Connector (CN3)You can attach up to two floppy disk drives to the PCA-6184's onboard connector. You can use 3.5" (720 K

PCA-6184 User’s Manual 182.4 USB Ports (CN6)The PCA-6184 provides four USB (Universal Serial Bus) interfaces, which give complete Plug & Play and

192.6 10/100Base-T Ethernet Connectors (CN8 and CN34)The PCA-6184 is equipped with one or two high-performance 32-bit PCI-bus Ethernet interfaces, wh

PCA-6184 User’s Manual 20Different devices implement the RS-232 standard in different ways. If you are having problems with a serial device, be sure t

212.10 Infrared (IR) Connector (CN13)This connector supports the optional wireless infrared transmitting and receiving module. This module mounts on

iii Table of ContentsContentsChapter 1 Hardware Configuration ...21.1 Introduction ...

PCA-6184 User’s Manual 222.12 Front Panel Connectors (CN16, 17, 18, 19, 21)There are several external switches to monitor and control the PCA-6184.2.

232.12.3 Reset (CN18)Many computer cases offer the convenience of a reset button. Connect the wire from the reset button.2.12.4 HDD LED (CN19)You can

PCA-6184 User’s Manual 242.13 ATX Power Control Connectors (CN20)Note:Connect to the CN1 on the Advantech backplane to enable the ATX function, 5V st

25CHAPTER 3Award BIOS SetupThis chapter describes how to set the card’s BIOS configuration data.

PCA-6184 User’s Manual 26Chapter 3 Award BIOS Setup3.1 IntroductionAward’s BIOS ROM has a built-in setup program that allows users to modify the bas

273.3 Standard CMOS SetupChoose the “Standard CMOS Features” option from the “Initial Setup Screen” menu, and the screen below will be displayed. Thi

PCA-6184 User’s Manual 283.4 Advanced BIOS FeaturesThe “Advanced BIOS Features” screen appears when choosing the “Advanced BIOS Features” item from

29Allows the system to skip certain tests while booting. It will reduce the time needed to boot the system.3.4.6 First/Second/Third/Other Boot Device

PCA-6184 User’s Manual 303.4.15 APIC ModeThis setting allows selecting an OS with greater than 64MB of RAM. Commands are "Enabled" or "

313.5.1 DRAM Timing SelectableThis item allows you to control the DRAM speed. The Choice: Host-Clock, CLK-33M.3.5.2 CAS Latency TimeThis controls the

PCA-6184 User’s Manual iv2.7 Serial Ports (CN9: COM1; CN10: COM2) ... 19Table 2.1:Serial port connections (COM1, COM2)) ... 192.8 P

PCA-6184 User’s Manual 32warded to the AGP without any translation. The Choice: 4M, 8M, 16M, 32M, 65M, 128M, 256M. 3.5.7 Memory Frequency For Onboard

333.6 Integrated Peripherals3.6.1 On-Chip Primary/Secondary PCI IDEIf you enable IDE HDD Block Mode, the enhanced IDE driver will be enabled. Leave I

PCA-6184 User’s Manual 34When enable, this field allows you to connect your floppy disk drives to an onboard floppy disk drive connector instead of a

35This field sets the address of the on-board parallel port connector. You can select either 3BC/IRQ7, 378/IRQ7, 278/IRQ5 or Disabled. If you install

PCA-6184 User’s Manual 36This item allows you to select power supply type-- AT or ATX3.7.2 Power ManagementThis category allows you to select the type

373.7.6 CPU THRM-ThrottlingThis field allows you to select the CPU THRM-Throttling rate. The choices: 12.5%, 25.0%, 37.5%, 50.0%, 62.5%, 75.0%, 87.5%.

PCA-6184 User’s Manual 383.8.2 Reset Configuration Data3.8.3 Resources controlled by BIOSBIOS can automatically configure all the boot and Plug and Pl

393.9.4 +5V/+12V/-5V/-12VThis shows you the voltage of +5V/+12V/-5V/-12V3.9.5 Beep when FAN BelowWhile the speed of FAN is below 3000 RPM, the system

PCA-6184 User’s Manual 40either “Setup” or “System” from the “Advanced BIOS Features” menu.3.12 Save & Exit SetupIf you select this and press <

41

v Table of Contents3.5.3 Active to Precharge Delay ... 313.5.4 DRAM RAS#-to-CAS Delay...

PCA-6184 User’s Manual 42

43 Chapter 4 CHAPTER 4Chipset Software Installation UtilityThis utility software installs to the Win-dows INF files that outline to the oper-ating sy

PCA-6184 User’s Manual 44Chapter 4 Chipset Software Installation Utility4.1 Before you beginTo facilitate the installation of the enhanced display d

45 Chapter 4 4.2 IntroductionThe Intel® Chipset Software Installation (CSI) utility installs to the target system the Windows INF files that outline

PCA-6184 User’s Manual 464.3 Installing the CSI Utility1. Insert the driver CD into your system's CD-ROM drive. In a few seconds, the software i

47 Chapter 4 2. Click "Next" when you see the following message3. Click "Yes" when you see the following message

PCA-6184 User’s Manual 484. Click "Next" when you see the following message5. When the following message appears, click "Finish" t

49 Chapter 5 CHAPTER 5AGP SVGA SetupThe PCA-6184 features an onboard VGA interface. This chapter provides instructions for installing and operating t

PCA-6184 User’s Manual 50Chapter 5 AGP SVGA Setup5.1 Before you beginTo facilitate the installation of the enhanced display device drivers and utili

51 Chapter 5 5.2 Features• Built-in ATI RAGE 128 PRO 4XL multimedia accelerator• Supports AGP 4X mode with sideband addressing and AGP texturing•

PCA-6184 User’s Manual vi3.9.1 CPU Warning Temperature ... 383.9.2 Current CPU Temperature ...

PCA-6184 User’s Manual 521. In the Setup, click on "next."2. In the Installation Information, choose turbo mode or standard. Then click on &

53 Chapter 5 3. The installation is complete click on "Yes" to restart the system.

PCA-6184 User’s Manual 54

55 Chapter 6 CHAPTER 6LAN ConfigurationThe PCA-6184 features onboard dual 10/100Base-T Ethernet LAN. This chapter gives detailed information on Ether

PCA-6184 User’s Manual 56Chapter 6 LAN Configuration6.1 IntroductionThe PCA-6184 features single or dual 32-bit 10/100 Mbps Ethernet net-work inter

57 Chapter 6 6.4 Windows NT Drivers (Intel 82559) Setup Procedure1. In the "Windows NT" screen, click on "Start" and select &qu

PCA-6184 User’s Manual 582. In the "Network" window, select the "Start Search" tab. Then click on "Next".3. In the "

59 Chapter 6 4. When the "Insert Disk" window appears, insert the utility CD into the CD-ROM drive. The correct file path is D:\Drv_Lan\825

PCA-6184 User’s Manual 606. In the "Microsoft TCP/IP Properties" window, select the "IP Address" tab. Then select "Specify an

61 Chapter 6 6.5 Windows 2000 Drivers (Intel 82559) Setup Proce-dure1. In the "Windows 2000" screen, click on " Start" and selec

vii Table of ContentsAppendix B Pin Assignments ...94B.1 IDE Hard Drive Connector(CN1, CN2)...

PCA-6184 User’s Manual 623. In " Device Manager" screen, click on "Intel® PRO/100+ Server Adapter (PILA84708) #2. Then click on mice&a

63 Chapter 6 6. Following the highlighted item, and click on "Next".7. Click on "Have Disk".8. Key in "D:\Drv_Lan\D_82559&qu

PCA-6184 User’s Manual 649. To highlight the following item, and click "Next".10. Click "Next".11. Click on "Yes"

65 Chapter 6 12. Click "Finish" to complete the installation.

PCA-6184 User’s Manual 66

67 Chapter 7 CHAPTER 7Onboard Security SetupThis chapter explains OBS concepts and provides instructions for installing the relevant software drivers

PCA-6184 User’s Manual 68Chapter 7 Onboard Security Setup7.1 IntroductionOnboard security (OBS) functions monitor key hardware. They help you mainta

69 Chapter 7 2. When you will see the following message, make sure you have closed all other programs, then click on "OK."3. Click on the s

PCA-6184 User’s Manual 704. When you see the following message, click on "OK" to complete the installation.7.3 Windows NT Drivers Setup Pro

71 Chapter 7 2. Click "Next" when you see the following message.3. Click "Next" when you see the following message.

PCA-6184 User’s Manual viiiB.21 SM Bus Connector (CN29) ... 106Table B.21:SM Bus Connector (CN 29)...

PCA-6184 User’s Manual 724. Click "Next" when you see the following message.5. Click "Finish" when you see the following message.

73 Chapter 7 6. Click "OK" to restart Windows.7.4 Using the OBS Hardware Doctor UtilityAfter completing the setup, all the OBS functions a

PCA-6184 User’s Manual 741. From the desktop of Windows, click on "Start" and select "Pro-grams" and then "OBS Hardware Docto

75 Chapter 8 CHAPTER 8Ultra ATA Storage Driver SetupThis driver must be installed to use the Intel® Ultra ATA controller to improve storage subsystem

PCA-6184 User’s Manual 76Chapter 8 Ultra ATA Storage Driver Setup8.1 IntroductionThis driver takes advantage of the latest Intel ® Ultra ATA control

77 Chapter 8 8.3 Installation1. Insert the driver CD into your system's CD-ROM drive. In a few seconds, the software installation main menu app

PCA-6184 User’s Manual 782. Click on "Next" when you see the following message3. When you see the following message, click on "Yes"

79 Chapter 8 4. Click on "Next" when you see the following message.5. Click on "Next" when you see the following message.

PCA-6184 User’s Manual 806. When the following message appears, click "Finish" to complete the installation and restart Windows.

81 Chapter 8 8.4 Displaying Driver Information1. From the desktop of Windows, click on "Start" and select "Pro-grams." Then sele

1CHAPTER1General InformationThis chapter provides background information on the PCA-6184. It shows you how to configure the card to match your applica

PCA-6184 User’s Manual 82

83 Appendix A AppendixAProgramming the Watchdog TimerThe PCA-6184 is equipped with a watchdog timer that resets the CPU or generates an interrupt if

PCA-6184 User’s Manual 84Appendix A Programming the watchdog timerA.1 Programming the Watchdog TimerThe PCA-6184's watchdog timer can be used

85 Appendix A Unlock W83627HSelect register of watchdog timerEnable the function ofthe watchdog timerUse the function of the watchdog timerLock W8362

PCA-6184 User’s Manual 86Table A.1: Watchdog Timer RegistersAddress of register (2E) AttributeRead/Write Value (2F) and description87 (hex) ----- Writ

87 Appendix A A.1.4 Example Program1. Enable watchdog timer and set 10 sec. as time-out interval;----------------------------------------------------

PCA-6184 User’s Manual 88;-----------------------------------------------------------Dec dx ; Set second as counting unit Mov al,0f5hOut dx,alInc dxIn

89 Appendix A ;-----------------------------------------------------------Dec dx ; Enable the function of watchdog timerMov al,30hOut

PCA-6184 User’s Manual 90Out dx,al ;-----------------------------------------------------------Mov al,07h ; Select registers of

91 Appendix A Out dx,al ;-----------------------------------------------------------Mov al,07h ; Select registers of watchdog